iboats - The #1 Store For Everything Boating
    Bookmark and Share

Seloc Publishing Sterndrive Engine

Typical index for Maintenance and Repair operations
Covers engine and drive systems

  • Alternator
    • Assembly
    • Cleaning
    • Disassembly
    • Precautions
    • Removal & Installation
    • Testing
  • Anchors
  • Anodes (Zincs)
    • Inspection
    • Servicing
  • Audio Warning System
  • Balance Shaft -
  • Battery
    • Battery Cables
    • Battery Chargers
    • Battery Construction
    • Battery Location
    • Battery Ratings
    • Battery Terminals
    • Checking Specific Gravity
    • Cleaning
    • Dual Battery Installation
    • Marine Batteries
    • Storage
  • Battery Gauge
    • Removal & Installation
    • Testing
  • Bell Housing
    • Adjustment
    • Inspection
    • Removal & Installation
  • Boat Maintenance
    • Anodes (Zincs)
    • Batteries
    • Inside The Boat
    • The Boat'S Exterior
  • Boating Safety
    • Regulations For Your Boat
    • Required Safety Equipment
    • Equipment Not Required But Recommended
    • Courtesy Marine Examinations
  • Booster Cylinder
  • Compact Hydraulic System
    • Hydraulic Fluid
    • Steering Unit
  • Control Valve
  • Breaker Point Ignition System
    • Adjustment-Dwell Meter
    • Adjustment-Feeler Gauge
    • Description
    • Distributor
    • Distributor Cap And Rotor
    • Ignition Coil
    • Removal And Installation
    • Troubleshooting
  • Buy Or Rebuild
  • Camshaft -
  • Carbureted Fuel System
    • Carburetor
    • Fuel Pump
    • Operation
    • Troubleshooting
  • Carburetor
    • Adjustment
    • Assembly
    • Cleaning & Inspection
    • Description
    • Disassembly
    • Removal & Installation
  • Charging System
    • Alternator
    • General Information
    • Troubleshooting
  • Combination Manifold
  • Compact Hydraulic System
    • Hydraulic Fluid
    • Steering Unit
  • Control Valve
  • Cool Fuel System
  • Cooling Systems
  • Cooling System -Draining & Filling
    • Seawater System
    • Closed System
  • Cooling System - Flushing The System
  • Cooling System - Level Check
  • Cooling System -Pressure Test
  • Courtesy Marine Examinations
  • Crankshaft Pulley/Torsional Damper
  • Crossover
  • Cruiselog
    • Removal & Installation
    • Testing
  • Cylinder Compression
  • Cylinder Head
    • Assembly
    • Disassembly
    • Inspection
    • Refinishing & Repairing
    • Removal
  • Cylinder Head Cover
  • Determining Engine Condition
  • Diagnostic Trouble Code Charts
  • Diagnostic Trouble Codes (Dtc)
    • Clearing Codes
    • Reading Codes
  • Digital Distributorless Ignition System (DDIS)
    • Description
    • Ignition Amplifier
    • Ignition Coil
    • Motion Sensor
    • Troubleshooting
  • Distributor - Breaker Points
    • Disassembly & Assembly
    • Installation
    • Removal
  • Distributor
    • Assembly
    • Cleaning And Inspecting
    • Disassembly
    • Installation
    • Removal
  • Distributor Cap
  • Distributor Cap And Rotor - Breaker Points
  • Drain Diagrams
  • Driveshaft Housing (Upper Unit)
    • Description
    • Gear Ratio Identification
    • Removal & Installation
    • Disassembly & Assembly
  • Dual Power Trim System
    • Relay Replacement
    • Diode Module Replacement
  • ECM Pin Locations
  • Electrical
    • Basic Electrical Theory
    • Battery
    • Charging System
    • Electrical Components
    • Ignition System
    • Instruments And Gauges
    • Jumper Wires
    • Multi-Meters
    • Starter Circuit
    • Test Equipment
    • Test Lights
    • Multi-Meters
    • Sending Units And Switches
    • Troubleshooting
    • Wire And Connector Repair
    • Wiring Diagrams
  • Electronic Control Module
  • Electronic Fuel Injection
    • Cool Fuel System
    • Description And Operation
    • Diagnostic Trouble Codes (DTC)
    • Electronic Control Module (ECM)
    • Engine Coolant Temperature Sensor (ECT)
    • Fuel Boost Pump (Electric)
    • Fuel Injectors
    • Fuel Meter Cover
    • Fuel Pressure Regulator
    • Fuel Pump - Manual
    • Fuel Pump Relay
    • Fuel Rail And Injectors
    • Idle Air Control Valve (IAC)
    • Intake Air Temperature Sensor (IAT)
    • Knock Sensor (Ks)
    • Manifold Absolute Pressure Sensor (Map)
    • System Diagnosis
    • Throttle Body
    • Throttle Body Adapter Plate
    • Throttle Position Sensor (TP)
    • Vapor Separator Tank (VST)
  • Electronic Spark Timing System (Est)
    • Description
    • Distributor
    • Distributor Cap
    • Ignition Coil
    • Troubleshooting
  • Emergency (Lanyard) Stop Switch
  • Engine
    • Engine And Drive Maintenance
      • Belts
      • Breaker Points And Condenser
      • Cylinder Compression
      • Flame Arrestor
      • Fuel Filter
      • Fuel/Water Separator
      • Idle Speed And Mixture
      • Ignition Timing
      • PCV Valve
      • Serial Number Identification
      • Spark Plugs
      • Spark Plug Wires
      • Thermostat
      • Valve Adjustment
  • Engine Block
    • Assembly
    • Disassembly
    • General Information
    • Inspection
    • Refinishing
  • Engine Coolant Temperature Sensor (ECT)
  • Engine Identification
  • Engine Mechanical
    • Combination Manifold
    • Cylinder Head
    • Cylinder Head Cover
    • Engine
    • Engine Identification
    • Flywheel
    • Front Cover, Oil Seal, Camshaft And Gear
    • General Information
    • Oil Pan
    • Oil Pump
    • Rear Main Seal
    • Rocker Arms And Push Rods
    • Torsional Damper
    • Valve Adjustment
  • Engine Oil
    • Oil Level Check
    • Oil & Filter Change
  • Engine Overhaul Tips
  • Engine Preparation
  • Engine Reconditioning
    • Buy Or Rebuild
    • Cylinder Head
    • Determining Engine Condition
    • Engine Block
    • Engine Overhaul Tips
    • Engine Preparation
    • Engine Start-Up And Break-In
  • Engine Start-Up And Break-In
    • Starting The Engine
    • Breaking It In
    • Keep It Maintained
  • Equipment Not Required But Recommended
    • Second Means Of Propulsion
    • Bailing Devices
    • First Aid Kit
    • Anchors
    • VHF-FM Radio
    • Tools And Spare Parts
  • Exhaust Bellows
  • Exhaust Manifold
  • Fasteners, Measurements And Conversions
    • Bolts, Nuts And Other Threaded Retainers
    • Standard And Metric Measurements
    • Torque
  • Fire Extinguishers
  • Firing Orders
  • First Aid Kit
  • Flame Arrestor
  • Flow Diagrams
  • Fluid Disposal
  • Fluids And Lubricants
    • Cooling System
    • Engine Oil
    • Fluid Disposal
    • Fuel And Oil Recommendations
    • Stern Drive Unit
    • Power Steering
    • Power Trim Pump
    • Stern Drive Unit
    • Transmission Fluid
  • Flywheel
  • Front Cover And Oil Seal
  • Front Cover, Oil Seal, Camshaft And Gear
  • Fuel And Combustion
    • Carbureted Fuel System
    • Carburetor Application Chart
    • Combustion
    • Electronic Fuel Injection
    • Fuel
  • Fuel And Oil Recommendations
  • Fuel Boost Pump (Electric)
  • Fuel Filter
  • Fuel Gauge
    • Hookup
    • Removal & Installation
    • Testing
    • Troubleshooting
  • Fuel Injectors
  • Fuel Meter Cover
  • Fuel Pressure Regulator
  • Fuel Pump
    • Electric
    • Mechanical
  • Fuel Pump - Manual
  • Fuel Pump Relay
  • Fuel Rail And Injectors
  • Fuel Tank Sending Unit
  • Fuel/Water Separator
  • Gear Housing (Lower Unit)
    • Description
    • Removal & Installation
    • Disassembly
    • Cleaning And Inspecting
    • Assembly
  • Gear Ratio Identification
  • Gimbal Ring
  • Gimbal Bearing
  • Gimbal Housing/Transom Plate
  • Gimbal Ring
  • Heat Exchanger
    • Cleaning
    • Testing
  • How To Use This Manual
    • Can You Do It?
    • Where To Begin
    • Avoiding Trouble
    • Maintenance Or Repair?
    • Directions And Locations
    • Professional Help
    • Purchasing Parts
    • Avoiding The Most Common Mistakes
  • Idle Air Control Valve (IAC)
  • Idle Speed And Mixture
  • Ignition Amplifier - DDIS
  • Ignition Coil - Breaker Points
  • Ignition Module
  • Ignition Switch
  • Ignition System
    • Breaker Point Ignition System
    • Digital Distributor-less Ignition System (DDIS)
    • Electronic Spark Timing System (Est)
    • Thunderbolt Ignition System
  • Ignition Timing
  • Instruments And Gauges
    • Battery Gauge
    • Cruise log
    • Fuel Gauge
    • Oil And Temperature Gauges
    • Speedometer
    • Tachometer
  • Intake Air Temperature Sensor (IAT)
  • Intake Manifold
  • Knock Sensor (Ks)
  • Lubrication Points
    • Throttle Cable
    • Shift Cable And Transmission Linkage Pivot Points
    • Steering System
    • Tie Bar Pivot Points
    • Engine Coupler/U-Joint Splines
    • Propeller Shaft
  • Manifold Absolute Pressure Sensor (Map)
  • Manual Steering System
    • Steering Cable
    • Swivel Ring
  • Motion Sensor - DDIS
  • Oil And Temperature Gauges
    • Removal & Installation
    • Testing
    • Troubleshooting
  • Oil Pan
  • Oil Pressure Sending Unit
  • Oil Pump
  • PCV Valve
    • Inspection
    • Removal & Installation
  • Personal Flotation Devices
  • Power Steering Cooler
  • Power Steering Pump
  • Power Steering System
    • Bleeding The System
    • Booster Cylinder
    • Control Valve
    • Description
    • Fluid Level
    • Power Steering Cooler
    • Power Steering Pump
    • Power Steering Unit
    • Steering Cable
    • Steering Cable Guide Tube
    • Testing
  • Power Steering Unit
  • Power Trim And Tilt
    • Description
    • Dual Power Trim System
    • Pump Assembly
    • Service Precautions
    • System Bleeding
    • System Testing
    • Trim Cylinder
    • Trim Limit Switch/Trim Position Sender
  • Power Trim Pump
  • Pressure Cap
  • Propeller(s)
  • Rear Main Seal
  • Rear Main Seal Retainer
  • Regulations For Your Boat
    • Documenting Of Vessels
    • Registration Of Boats
    • Numbering Of Vessels
    • Hull Identification Number
    • Capacity Information
    • Certificate Of Compliance
    • Ventilation
  • Required Safety Equipment
    • Types Of Fires
    • Fire Extinguishers
    • Warning System
    • Personal Flotation Devices
    • Sound Producing Devices
    • Visual Distress Signals
  • Rocker Arms And Push Rods
  • Rotor/Sensor Wheel
  • Safety In Service
    • Do'S
    • Don'Ts
  • Sea Strainer
  • Seawater Pick-Up Pump
    • Removal & Installation
    • Disassembly & Assembly
  • Seawater Pick-Up Pump - Stern Drive
  • Sending Units And Switches
    • Audio Warning System
    • Emergency (Lanyard) Stop Switch
    • Fuel Tank Sending Unit
    • Ignition Switch
    • Oil Pressure Sending Unit
    • Start/Stop Switch Panel
    • Water Temperature Sender
    • Water Temperature Switch
  • Sensor - Thunderbolt
  • Serial Number Identification
    • Engine
    • Stern Drive
    • Transom Assembly
  • Shift Cable
  • Shift Cut-Out Switch
  • Solenoid
  • Spark Plugs
    • Inspection & Gapping
    • Reading Spark Plugs
    • Removal & Installation
    • Spark Plug Heat Range
    • Spark Plug Service
  • Spark Plug Wires
  • Specifications
    • Alternator
    • Capacities
    • Carburetor
    • Carburetor Application Chart
    • Conversion Factors
    • Engine Mechanical
    • Metric Bolts
    • SAE Bolts
    • Starter
    • Torque
    • Tune-Up
  • Speedometer
    • Removal & Installation
    • Testing
  • Spring Commissioning
    • Fluid Level
    • Checking For Water
    • Drain And Refill
  • Start/Stop Switch Panel
  • Starter Circuit
    • Description And Operation
    • Solenoid
    • Starter Motor
    • Troubleshooting
  • Starter Motor
    • Description & Operation
    • Disassembly & Assembly
    • Precautions
    • Removal & Installation
    • Testing
    • Troubleshooting
  • Steering Cable
    • Manual
    • Power
  • Steering Cable Guide Tube
  • Swivel Ring
  • Stern Drive Unit
    • Bell Housing
    • Checking For Water
    • Description
    • Drain And Refill
    • Driveshaft Housing (Upper Unit)
    • Exhaust Bellows
    • Fluid Level
    • Gear Housing (Lower Unit)
    • Gimbal Housing/Transom Plate
    • Gimbal Ring
    • Propeller (S)
    • Removal & Installation
    • Shift Cable
    • Transom Assembly
    • Trim Cylinder
    • Troubleshooting
    • U-Joint Bellows
  • Swivel Ring
  • System Diagnosis
    • Diagnostic Trouble Codes (Dtc)
    • EFI System/Ignition Relay Check
    • Engine Cranks But Will Not Run
    • Fuel System Diagnosis
    • Fuel System Electrical Test
    • Idle Air Control Valve Functional Test
    • Ignition System Check
    • Lanyard Stop Circuit Check
    • No MIL Or No DLC Data
    • Precautions
    • Idle Air Control Valve Functional Test
  • Tachometer
    • Removal & Installation
    • Testing
  • Thermostat
    • Removal & Installation
    • Testing
    • Throttle Body
  • Throttle Body Adapter Plate
  • Throttle Position Sensor (TP)
  • Timing Chain And Sprockets/Gears
  • Tools
    • Electronic Tools
    • Hand Tools
    • Measuring Tools
    • Other Common Tools
    • Special Tools
  • Tools And Equipment
    • Chemicals
    • Safety Tools
  • Torsional Damper
  • Transom Assembly
    • Description
    • Gimbal Bearing
    • Shift Cable
    • Shift Cut-Out Switch
    • Exhaust Bellows
  • U-Joint Bellows
  • Bell Housing
  • Gimbal Ring
    • Gimbal Housing/Transom Plate
  • Transmission
  • Transmission Fluid
  • Transom Assembly
    • Bell Housing
    • Description
    • Exhaust Bellows
    • Gimbal Bearing
    • Gimbal Housing/Transom Plate
    • Gimbal Ring
    • Shift Cable
    • U-Joint Bellows
  • Trim Cylinder
    • Disassembly & Assembly
    • Removal & Installation
  • Trim Limit Switch/Trim Position Sender
    • Adjustment
    • Removal & Installation
  • Trim Pump Assembly
    • Removal & Installation
    • Disassembly & Assembly
  • Troubleshooting
    • Breaker Points
    • Charging System
    • Cooling Systems
    • DDIS
    • Electrical System
    • Est
    • Fuel Gauge
    • Oil & Temperature Gauges
    • Starter
    • Starting System
    • Thunderbolt
  • U-Joint Bellows
  • Vacuum Diagrams
  • Valve Adjustment
  • Vapor Separator Tank (VST)
  • VHF-FM Radio
  • Visual Distress Signals
  • Water (Engine) Circulating Pump
  • Water Pump/Seal Carrier
  • Water Temperature Sender
  • Water Temperature Switch
  • Winter Storage
  • Wire And Connector Repair
  • Wiring Diagrams
    • Electrical
    • Fuel Injection
    • Trim/Tilt

Home | Boats | New Boats | New Boat Manufacturers | Outboard Motors | Boat Dealers
Boat Insurance | Repair | Boating Forum Directory | Boats for Sale | Sell a Boat | Boat Covers | Propellers | Loans
Contact Us | Terms of Use | Privacy Practices | Legal | Boat Manufacturers

1-800-914-1123 (Toll Free)
001-801-571-0071 (for International Calls)
Copyright © 1999- iboats, inc. All rights reserved