Search results

  1. C

    Electric fuel pump conversion

    Electric is a real bad idea, unless wired with a proper relay driven off the stator or something else that goes dead if the engine stalls. Otherwise, fuel will keep pumping, even if the engine stalls, possibly filling the bilge or cockpit with gasoline. Gee, fuel pump rebuild kits are real...
  2. C

    Two Piling Boat Lift

    We use the "elevator lifts" and two pilings for larger boats here in NJ. They seem to do a good job.
  3. C

    Merc outboard serial number question

    The block part number should differentiate a 115HP from the 150HP. I also think the transfer covers are different. Also, the 150HP motor will have a power port (round hole) in the piston skirt on the transfer cover side. If you pull a transfer cover, you should see the power port.
  4. C

    No spark on Merc 85hp

    The CDIElectronics web site should have a battery-powered CDI ignition test. It will test everything but the trigger. If the test produces spark, suspect the trigger is bad.
  5. C

    2001 40ELPT 4S issue

    On my older Mercs, 1-1/2 turns open is the starting point.
  6. C

    No spark on Merc 85hp

    What year or better yet, does it have a distributor and 4 cylinders? On the shift slider. Normally fwd is toward the front of the boat, and reverse is toward the back. Neutral is about in the middle of the shift slide track.
  7. C

    Control replacement/update opinions

    46 MPH out of a 3.0 might be a record. I can't imagine where the play would be in a sterndrive, I do not know a lot about them.
  8. C

    I need help, boat runs rough and stalls. I pumped new gas and lots more.. I need help

    The choke is immobilized by the throttle under closed and open settings. Loosen the screws around the choke black plastic housing. Open the throttle and turn the choke housing until the choke just closes....no more. If the choke plate moves with the choke housing, the mechanism is likely...
  9. C

    Help with lower unit

    Gee, what about telling us the year and HP? Newer motors can usually get replacement gearcases from SEI.
  10. C

    Control replacement/update opinions

    Gee, that is a real lot of play. My neighbor had a fast (50mph) boat with a turn or more of play in the hydraulic steering. I am surprised I lived. I hope the new steering system fixes it.
  11. C

    Merc outboard serial number question

    It has the older style starter, like my 1973 850. I did not see the old ugly orange coil, like the '73's had. Does it have the newer black square rectifier or the old rectangular rectifier, with the colored decals? You might check the block part numbers. That could narrow it down.
  12. C

    Restoring a trailer vs replacing a trailer

    You might see if eastern marine has a longer tongue that will fit. They are a pretty good source for trailer parts. You may need to move the axle to restore balance.
  13. C

    Control replacement/update opinions

    You have a Mercruiser, right? Usually with power steering on the Mercruisers you do not need the NFB Steering systems. You could use a trim tab (anode) to get rid of some of the torque steer, if it bothers you. Remember NFB steering only holds the steering wheel where you let it go. You...
  14. C

    I need help, boat runs rough and stalls. I pumped new gas and lots more.. I need help

    Does the choke plate close when the engine is cold? It sounds like the accelerator pump is working, but you should verify. What do the spark plugs look like?
  15. C

    2001 40ELPT 4S issue

    Check compression and spark to make sure all cylinders are healthy. Is there a mixture screw on the carb? If so, can you richen it a bit and see if that helps? The 2 cycle Mercs need a bit of a rich idle mixture to accelerate, not sure about the 4 cycle Mercs.
  16. C

    2013 Mercury 20 1F20201HK Leaking gas out the carb mouth (Solved)

    Carbs work on the Bernoulli principle. Higher velocity air has a lower pressure, than lower velocity air. So if gas was sprayed thru the carb jets into the throat, because of that low pressure, I would think it would then be sucked into the engine, using the same airstream. I would expect the...
  17. C

    Sea Nymph fishing boat decals

    There are duplicate decal makers on the internet. They make decals for outboard engines and other kinds. You might see if they have something or can make you something.
  18. C

    Mercury 85HP Thunderbolt Ignition Series??? Whats missing??

    The IL6 motors converted to ADI ignition in mid 1979. The IL4 motors converted to ADI ignition in 1975, if memory serves.
  19. C

    Mercury 85HP Thunderbolt Ignition Series??? Whats missing??

    Merc850 is likely correct. I do not know if any 1150/1500 had the dual triangle fuel pumps. Some might have. A lot had the single figure 8 fuel pumps. With some transfer covers from the motors with that figure 8 fuel pump, and some creativity, you could probably retrofit it. The ign wiring...
  20. C

    what to use to line ski locker

    Anything you glue to the ski well wall will allow moisture between the lining material and the FG. It cannot practically be kept out using glue, caulk etc. Mold can develop in that moisture. If you want a solid material on the ski well sides and bottom, it must not absorb moisture and allow...
Top