Recent content by bostonpilot

  1. B

    Help!! - 15hp Mariner starting problems

    I'm stumped and could use some ideas from the group. I have a 1991 15hp Mariner. At the end of last season, it started running like crap. The only way to get it started was to shim the throttle open adn once it started, it seemed like it was only running on 1 cylinder. Over the winter, I...
  2. B

    I'm stumped. Tiller disassembly

    Hi All, I have a Mariner 15 hp outboard (1991, OAxxxxxx series), and the kill switch at the end of the tiller has stopped working (tested with an ohm meter through the wiring). So, I was looking at it last night trying to figure out to get into the tiller in order to replace the switch. I'm...
  3. B

    Mariner prop advise

    Hi All. I asked a similar question a few days back on the prop forum, but wasn't able to get much useful info, so I thought I'd ask here. I have 1991 15hp Mariner on my 25', 3000lb full keel sailboat. I have been finishing up the last bits of winter service and repair work on the motor and...
  4. B

    Some prop advice

    Hi All, I am looking for some advice in an area that I don't feel that I have enough experience to make a call. I have a 1991 15hp Mercury Mariner 2 cyl/2 stroke motor (ser. # OCxxxx series) on a 25 ft, sailboat that displaces ~4500lb, and has ~2500lb of ballast in the keel. I'm finishing up...
  5. B

    Factory maint. manual - source?

    Hi all, I've got the nearly usless Seloc manuals for both of my mercury outboards, but I'd really like to get the factory manual that would actually be useful. I've been looking around for one, but to no avail. Any ideas? The primary motor I care about is a 15hp (1991) Mariner 15hp. Thanks!
  6. B

    Ignition Advice

    Hi All, I think I know the answer to this problem, but thought I'd run it by the group to get some second opinions (read=cheaper) on the problem. I have a 15hp Mariner (1989/OAxxx series). Symptom: Good spark on top cylinder with no, or occasional very weak, spark on the bottom cylinder...
  7. B

    Thermostats

    How often do you guys replace your thermostat in a small hp (15) outboard? I've been doing it annually (operating in salt water), but it feels like a bit of overkill. Thoughts?
  8. B

    Merucry 2.2hp - point not available - help

    I was looking to buy some new ignition components for my 2.2hp mercury but according to mercurypartsexpresss.com as well as the other vendors I usually buy parts from, they are no longer available. Any good ideas where I can ronud some up?
  9. B

    Bearing Carrier tool - p/n 91- 13664 - Does anyone have one?

    Does anyone have this tool from mercury for removing bearing carriers from lower ends? I am trying to track down the dimensions of this tool so that I can make myself one. Can anyone help me out with this?
  10. B

    Lower unit oil leak - 15hp Mariner

    Hi, It appears as though the lower unit on my 15 hp mariner is dripping oil from around the prop. The two new oil seals and O-ring are easily purchased, but I am wondering how much of a nightmare I am facing to replace them. Any advice? From looking at my repair manual's description, it...
  11. B

    Help with an attack plan - 15hp mariner with idle and power issues

    Hi All, I have a 15hp Mariner (OCxxxx series) that went from running great to feeling pretty sick this season. I have some ideas, but I'd like to get some advice on an attack plan from the knowledge base here. So, I won't pollute your minds with my ideas and opinions - I'd rather get your...
  12. B

    Mariner 15 Spark Plug Wires

    Hi. I'm sure this has been answered a bunch of times before, but I can't find a definitive answer in a forum search. I've got a 15hp Mariner (s/n OCxxxxxx series) that has a rough idle/lack of power problem(a discussion for a later thread) that I think has a weak spark element to it. So, I am...
Top