Search results

  1. B

    2002 mercury 200 2 stroke will not idle in neutral

    Just bought -150 hrs-always run with ethanol fuel and seafoam. Maiden voyage idle was set high wouldn't slow idle but ran great. I left it idling for half hour then another long idle down the canals twice. Today after sitting on anchor it would not stay idling in neutral-run 10 seconds and...
  2. B

    2002 mercury 200 2 stroke -oil alarms when in waves /boat rocking side to side

    Jhad the oil tank cap float replaced-no alarms when in calm water. Motor runs as it should and pumps water well.Waves and side to side rocking cause the alarm to go off each time the boat rocks.
  3. B

    Saltwater sitting in pontoon rotting from inside out

    just found saltwater had been sitting inside pontoon --just had a $$$ patch welded on rear wall of pontoon after discovering grey mushy film-am I too late? Is there anything to neutralize the salt residue inside the log?
  4. B

    2002 johnson 90 4 stroke pl4 st trim at control raises but will not lower the engine

    motor works fine at the motor switch but from the controls it will raise but not lower the engin
  5. B

    2002-3 johnson90 pl4 4 stroke flush/trim

    Is there a flushing port or ears? down trim works at motor not control-switch?
  6. B

    minnkota PD68 No power

    The motor turns ok and the pin is not sheared -how do I check to see if its fine lower unit or a burned controller?My I pilot controlled pontoon motor got stuck in milfoil and stopped.
  7. B

    no oil in gearcase during winter storage ramification

    1978 90 merc was stored with no plugs and empty gearcase in sub freezing temps also no fog-what problems could have developed?
  8. B

    2004 Mercury 40 hp 4 stroke -how reliable?

    I am looking a a 19' oddessy pontoon with a 40hp 4 stroke w/70 hrs--is there anything I should look for before my purchase?
  9. B

    1982 7.5hp do I need a waterpump or a thermostat

    Mists at idle or trolling speed-good stream a higher speeds
  10. B

    Do I have a bad impeller?

    1982 7.5 hp mercury-when trolling only a light spray but a good stream at higher speed
  11. B

    Oil loss in lower unit 1978 90 hp mercury

    Drained lower unit for winter refill and found a cup or 2 left in lower unit. Refilled and now I am concerned about running this year though no evidence of shavings when draining. Thoughts ? I am planning to pull unit to install new water pump kit because it seemed to take 15 seconds or more to...
  12. B

    1976 70hp evinrude steering removal at helm

    I have a rotary? coiled cable at the helm-and a stubborn rod in the tube. How do I disconnect the cable from the steering and/or get the cableout from the tube-(so far I managed to bang it about an inch). Bchappy
  13. B

    MinnKota PD 68 24V no power

    New motor-left foot control out in the rain- I have I- control and foot control attached at the same time. Motor is 24V but has no power. Batteries are charged with on board charger 2 bank charger. Last use- with I control - motor would not turn unless prop power was off. This a.m. prop...
  14. B

    zercom RTS battery size

    what size battery do I need for the RTS verticle?
  15. B

    Starter won't engage-engine pulls starts fine

    1975 70 hp sat idle for a month after running all summer.Installed a rebuilt starter two years ago. Turn key and only get a click. Replaced battery. Starter gear which engages flywheel does come up and I don't think even spins.Noticed some green corrosion in the wires near the battery terminal...
  16. B

    Merc 90 in line 6 carb issue symptom

    My 1978 model has stalls after a minute at full throttle. I tried injecting carb cleaner into each carb. The top two when injected almost stalled out the motor. The lower one made no difference in rpm's when injected. Could this be a teltale that it is not operating? I have change tanks,hoses...
  17. B

    Evinrude fuel tank OK on Mercury?

    If I change the motor end of the hose connection is it ok to use another mfg fuel tank? another question is it ok to direct connect the hose to the tank to permanently mount the hose?
  18. B

    1978 90 HP Merc stalls out at full throttle

    I ran 8 tanks of gas through it this spring-fuel bulb occasionally collapsed and had to pump it it to keep from completely stalling out.<br />Since then newplugs,pulled carb bowl fittings and drained/got new fuel/ and now here I am____<br />-at half speed it runs but I have to keep jockeying the...
Top