Search results

  1. K

    Weak water stream

    The water stream does not come out with much pressure on muffs or in the water. After a few minutes overheat alarm comes on. I am use to water squirting out of these hoses when running 2004 Merc 3cyl. 2 stroke ser#OT899429 1-I have put new water impeller. 2-New thermostat. 3-While t-stat out i...
  2. K

    Smoke from under engine cover

    I have a 2004 50hp 2 stroke Merc O/B, someone disconnected the warning buzzer, so i reconnected it and the buzzer buzzes constantly (bad temp sender ?). Also noticed while i had cover off and running that while throttling up engine it wants to hesitate and almost sounds like an exhaust leak then...
  3. K

    Oil injector

    Do you trust your injector to mix the oil proportionately. I ask because i just bought this boat with a 2004 Merc 50 2 stroke and the guy told me he always adds a gallon to the gas when he fills up! (20) gallon tank i think, but boat does not idle good (runs rich). I was wondering how to check...
  4. K

    Immediate help please

    I have a 2004 50hp 2 stroke. Trying to change impeller. I shifted into forward before starting to remove (or so i thought) and lower dropped an inch, i looked at shifter and it was not all the way forward so i tried to push forward and met resistence, pulled back into neutral and it went into...
  5. K

    Just bought a 2004 bentley 20ft

    It has a 2004 mercury 2 stroke (3 cyl) and found out the voltage regulator is bad, dealer says my serial # say's it's a jet drive ??? NOT! The part # they said i need is a voltage/ regulator kit but it does not look like the part i pulled off. What i pulled off looks like the part they had in...
  6. K

    Help with part #

    I have a Merc 2004 50ELPTO, the voltage regulator is bad (not charging) and smells like burnt electronics (both yellow wires were HOT to the touch and melting, coming from under flywheel). Dealer says the part is discontinued but a few is still available ($168). The part # they gave me was...
Top