Search results

  1. G

    Safety Switch Issues

    Disregard. Digging into the harness tucked under the console revealed that it was simply unplugged LOL.
  2. G

    Safety Switch Issues

    1994 2 stroke 75hp 3cyl. I just realized that the safety/man-overboard switch does not kill the engine... From what I understand, it should pull the CDMs to ground and cut the ignition. The wiring that I could see at the time appeared to be okay, but I haven't had the chance yet to really dig...
  3. G

    Spark Plug Half-Fouling

    Meant to follow up earlier, but I wanted to run the boat a bit to make sure. It turned out to be the fuel pump. No more bogging and the plug looks normal. I'm guessing it was just enough to cause a lean condition in the bottom cylinder. Thanks for all the advice!
  4. G

    90 HP Mercury 2-stoke troubleshooting starter

    It'll still spin while engaged. Mine got stuck in the flywheel and I thought I needed a new starter until I realized the positive terminal on the battery was just slightly loose. Make sure all power connections are solid - it needs a lot of current.
  5. G

    Spark Plug Half-Fouling

    Definitely fully seated on both ends, but I'll try swapping wires or testing the resistance.
  6. G

    Spark Plug Half-Fouling

    I've always just used stock components. It's been fine for years so I'd rather just stick to what Mercury recommends.
  7. G

    Spark Plug Half-Fouling

    So could this be caused by a lean condition in that cylinder? Perhaps it's only fouling closest to the intake?
  8. G

    Spark Plug Half-Fouling

    1994 Merc 75hp 2 stroke, 3-cyl. I've been having issues with surging at mid-throttle and discovered the bottom plug appeared half-burned. What would cause this? I decarbed the engine, put new plugs in, and it did the same thing to the new plugs after a quick outing.
  9. G

    Mercury 115 Tachometer Problem

    Did you check for AC voltage on the grey wire before switching it out? If so, what did you get?
  10. G

    75hp 2-stroke Bogs Mid-Throttle Only

    What kind of carb issues would cause it to only surge at mid-throttle?
  11. G

    75hp 2-stroke Bogs Mid-Throttle Only

    Alright I'll give that a try. I did a visual inspection of a couple of the lines when I replaced the inline fuel filter and they appeared okay inside, but I'll check the carb drain.
  12. G

    75hp 2-stroke Bogs Mid-Throttle Only

    1994 Merc 75hp 2-stroke started bogging while cruising. Noticed the primer bulb was empty (not sucked in) when this happened. Replaced both filters, fuel lines, new primer bulb, and removed anti-siphon valve. Now she only seems to bog down at mid-throttle. Not completely, but you can hear and...
  13. G

    Mercury 115 Tachometer Problem

    Following. Same tach issues and identical burned-looking VR wires on my '93 75hp 2 stroke.
  14. G

    Prop damage threshold

    Thanks everyone for the input. I think I'll just buy a new prop and before installing it, use it to make some kind of template/jig to measure blade deflection for the next time it happens (which is inevitable in the lower James River).
  15. G

    Prop damage threshold

    Considering I'm running an old 75hp 2-stroke 3cyl Merc, I'm afraid I wouldn't feel any prop vibrations lol. The weight balance would be fine, but a bent blade would still cause an uneven load while rotating I imagine... I like to overthink things especially when it comes to my beloved boat!
  16. G

    Prop damage threshold

    Went over a couple small logs that were lurking just under the surface of the water and two out of three blades on the prop appear to be slightly bent. Not a big deal and I've straightened out blades before, but I've always wondered - at what point does an unbalanced prop start to cause damage...
  17. G

    No water coming out the Merc tell tale now?

    Bottom contact or operating in turbulent dirty/sandy/chunky water can cause a blockage. Last summer I had mud dobbers, or whatever they were, trying to build nests in it all the time. I kept a length of 100lb mono fishing leader to snake it out at the ramp.
  18. G

    Fuel Delivery Issue

    Sorry for the long post... 1993 Mercury 75hp 2 stroke 3 cyl. Couple weeks ago, the engine started the bog at high speeds after cruising for about 30 mins. Stopped and squeezed the primer bulb a couple times and it ran fine for the next few hours of fishing (spot hopping - engine was stopped and...
  19. G

    1993 Bass Tracker Deck

    Does anyone happen to know if the rear deck platform on a 1993 Bass Tracker is wood or aluminum? I want to mount a trolling bar and was planning on using lag bolts if it was wood (which I assumed) but I've seen some places online that said their front decks were wood and the rear are aluminum...
  20. G

    Merc Trim/Tilt Leak

    I can see where it might seem like they're saying that in the caution note, but I edited the highlighting on the service manual page so the words aren't blocked. Maybe they're referring to other components besides the screws/springs/balls?
Top