Search results

  1. R

    Year of Motor - Johnson 140 HP

    I just picked up a used 140 Hp Johnson and would like to verify the year it was made. The Model ID is J140TLERR and the serial number is G03613784. I appreciate the help!<br />Rick
  2. R

    Shifter Linkage ID and possible diagram

    I have a 1997 20 Hp Mercury that I bought used on a zodiac. The Motor was setup with a remote shift/throttle assembly that I am not familar with and one of the cables has broken. The main shifter sends cables back to gear mounted where the hand held shifter/throttle handle would normally be...
  3. R

    1981 Johnson 115 Hp Not reaching RPMs

    My 115 Hp just started this. It use to idle around 1000 rpms. Now it idles around 700 rpms then dies. When running it at full throttle, it use to top out at 5500 rpms (30 knots) now it runs around 4500 rpms (22 knots). The fuel line has two filters, an inline (just changed it) no difference and...
  4. R

    OMC Shifter/throttle dis-assembly

    My key switch is broken. I started to dis-assemble the shifter throttle assembly and my manual does not cover this. I removed two of the three screws in the back, the third broke off & I had hoped to unscrew it with vice grips once I got the box apart, (but may end up drilling it out). I removed...
  5. R

    25 HP Mercury Shift cable

    I am working on a 25 HP mercury, not sure what year, but the shift cable comes back to gear mounted on the left front part of the motor, then on the top of this gear box is another short cable that goes into the motor and finishes the shifting system. I need to replace this short cable, does...
  6. R

    70 HP - 2000 Trim leaking down

    I have a 70 Hp - 2000 motor, I put the motor up using the power trim and leave it up and in about a week later it has slowly leaked down. When I check the trim fluid level it is full. Is there a bleed valve or something that could be causing this? Any ideas. Thanks
  7. R

    115 HP 1981 Johnson Wiring Harness / starter

    I have two intermitten problem electrical problem and am not sure if they are related or the correct way to fix them.<br />1. Sometimes when I turn off my motor, than when I turn the key to restart the engine nothing happens (no power), but I can wiggle the big red multi-connector inside the...
  8. R

    Charging system 115 HP Johnson 1981

    My charging system doesn't appear to be working properly and wanted to know if anyone has any ideas on what to check?<br />I took a volt meter and checked my voltage before starting my motor and it was 12.5 volts. I ran the boat 1000 rpms with no change in voltage at the battery, ran it around...
  9. R

    Johnson 1981- 115 HP Rectifier/votlage regulator

    I can start my boat up without any problem and run it as long as I want, but when I turn off the motor. When I go try to re-start the motor the starter clicks like it isn't getting enough voltage. I replaced the battery with a new 100 amp, and replaced the positive cable and terminal post. I am...
  10. R

    Tach acting up 1980 115 HP Johnson

    When I start my boat up the tach works fine for about 5 minutes, then drops to zero and stays there. If I shut off the motor and restart it, it will do the same thing. I have checked the connections they appear to be ok and rectifier is new. Does anyone have any suggestions for troubleshooting...
  11. R

    1980 115 HP Johnson Power trim leak

    I have a 1980 115 HP Johnson and replaced the power trim motor. The power trim works great until the fluid leaks out in about a month or so, then you have to refill it. It appears to seep out around the "o" rings on the main hydraulic piston. Can anyone explain or send me a step by step on how...
  12. R

    Power Trim Leaking

    I have a 1980 115 HP Johnson and replaced the power trim motor. The power trim works great until the fluid leaks out in about a month or so, then you have to refill it. It appears to seep out around the "o" rings on the main hydraulic piston. I know the correct way is to take it off the motor...
  13. R

    Swap Engines 115 HP to 140 HP Johnson

    I have a 1980 115 HP Johnson without VRO and aquired a Johnson 140 with ID G3613784 with VRO, not sure what year, but is clean & newer with rebuilt Lower unit. <br /><br />Questions are:<br />1. What is involved in changing these two engines, Electrically and Mechanically. <br /><br />2. The 140...
Top