Search results

  1. theorifice

    Alpha One Gen 1 Shifter Operation and Cable Movement

    Wouldn't the hole furthest from the arm be the longest travel? I'd love to find a manual for this controller but haven't had any luck. The shifter cables are the cables are the outer ones. Which hole give larger travel?
  2. theorifice

    Alpha One Gen 1 Shifter Operation and Cable Movement

    I measured the output on the other end of the control and at the idle positions, it's just at 2 7/8 (or a little under) which I think is the lowest end of the specification (3" +/- 1/8" according to achris). For this control, is there any adjustment that could increase the travel of the shift...
  3. theorifice

    Alpha One Gen 1 Shifter Operation and Cable Movement

    Yea. They both have the same behavior
  4. theorifice

    Alpha One Gen 1 Shifter Operation and Cable Movement

    On a Carver Santego 30 (1988) with dual controls connected to a pair of Alpha One Gen 1 drives (5.7) Three seasons ago, I changed the lower shift cables (they were closed to being seized up!) and after adjustment, all of the lower shift cable operations and measurements were in spec. In the...
  5. theorifice

    Where is the idle mix adjustment on this carb on a 5.7 350 with Thunderbolt IV?

    I looked around but not seeing an obvious location for the idle mix adjustment screw. What should I be looking for? I can't tell what kind of carb I have.
  6. theorifice

    Very difficult to shift into Neutral

    I have a similar problem right now with both engines. Often times, I can only apply the requisite force by shifting past the neutral position on the control. Once in a while, I'll get a smooth shift to neutral but it's rare. Recently - have adjusted shift interrupt (cutoff) switch to the...
  7. theorifice

    Power Steering Cooler Replacement - Access

    Ah yes - those. They kind of go around the block. There's a line that goes over the block that was "decommissioned" it seems. The previous owner (or even before) added a new line without taking the old one out. Actually there are LOTS of instances of this for all of the control cables in the boat.
  8. theorifice

    Power Steering Cooler Replacement - Access

    I'm not sure I'd be able to hoist out the generator while on the water. I don't think I'll have the option to pull the boat out at this point. Even removing the manifold is going to be tricky with the limited access :( I'm going to take a closer look at the parts of the generator that could be...
  9. theorifice

    Power Steering Cooler Replacement - Access

    Do you mean the red hose? That's the water feed for the generator's closed cooling system.
  10. theorifice

    Power Steering Cooler Replacement - Access

    I have a fairly severe power steering leak when engine is running (system under pressure). I haven't looked at exact leak location yet but all signs point to the cooler or hose attachments to cooler. Access to the cooler looks extraordinarily tight. I don't think I can replace it in the current...
  11. theorifice

    Alpha 1 Gen 1 oil fill hose

    I have the same setup on a 1987 Carver Santego. Dual Sterndrive. Was never quite clear if was necessary to drain and replace the reservoir for a gear oil change. As far as I can tell, it never even gets used up.
  12. theorifice

    Missing Anchor Bail

    It seems our anchor bail is missing. I can see the remnants of one on the port side. It looks to be mounted directly to the bow deck. I have not been able to find a suitable replacement through any online window shopping. Any suggestions? What risks should I be aware of for running without...
  13. theorifice

    '88 Mercruiser 5.7L Alpha One - Shifts into gear, but no Neutral

    How did you make it weaker?'
  14. theorifice

    Replacement for Raritan CH50CW

    It looks like my Raritan Crown head has had the elbow the connects freshwater to the top of the bowl replaced. The replacement does not have a siphon inlet and I am unable to hook up the treatment tank. The replacement part is CH50CW and is ~75$ with shipping. I'm having a hard time...
  15. theorifice

    How much power steering fluid does the system take (dual 5.7 Alpha 1 Gen 1)

    Whoops - I missed the original "took about 1 quart". Thanks
  16. theorifice

    How much power steering fluid does the system take (dual 5.7 Alpha 1 Gen 1)

    Thanks all - I'm fairly certain I have a leak now. How much fluid does the system hold?
  17. theorifice

    How much power steering fluid does the system take (dual 5.7 Alpha 1 Gen 1)

    How much power steering fluid does the system take (dual 5.7 Alpha 1 Gen 1)? I probably have a leak as I just filled up and bled last week and I was barely under low or maybe not bleeding properly.
  18. theorifice

    Very hard to steer towards starboard while underway

    We have a dual 5.7 Alpha 1 Gen 1 sterndrive boat. Took the boat out today and once underway at cruising speed (~2000 RPM) I found I could not turn the steering to starboard. I immediately got into neutral and found that steering returned. I found that only steering to starboard was affected...
  19. theorifice

    White Smoke on First Start on Muffs

    Is that an abnormal amount of steam? The portside engine has a little bit of the white "smoke" but appears to be much less. It was a cold humid day. Videos were taken ~9AM:
  20. theorifice

    White Smoke on First Start on Muffs

    First start on muffs of the season. I was unavailable between the time of haul out and harbor shrinkwrap so had boat winterized by a mechanic prior to winter storage. The starboard engine started up easily. I noted that there was more white smoke coming out of the exhaust. When I pulled the...
Top