Search results

  1. Bt Doctur

    No reverse after impeller replacement

    se106 is a replacement for the Alpha1 . easier to do in the stand but you can do it by just dropping the lower. lower splined rod fully clockwise ,prop locked CCW. Control box in full fwd, install lower making sure the lower shaft is in the upper section when raising the drive up . install...
  2. Bt Doctur

    Distributor Shaft Seal Replacement

    Grainger may be another source for the seal
  3. Bt Doctur

    Excessive "play" in Sea Star hydraulic steering

    system not bled correctly?
  4. Bt Doctur

    SERVICE MANUAL 2006 MAXUM 4.3L

    left you a message
  5. Bt Doctur

    Power steering pump cutting radiator hose - how did you guys fix yours?

    My 4.3 did the same from the belt coming apart.cut the hose where it rubbed and installed a 6inch steel nipple
  6. Bt Doctur

    Alpha Gen 2 Remote gear lube hose length

    13-14 is better to prevent you from breaking the plastic nipple on the transom
  7. Bt Doctur

    Mercury 350 mag No start

    First, exactly how did you winterize it? a soft click is usually the slave solenoid a hard clunk is a seized motor
  8. Bt Doctur

    MCM260 Problem

    First verify the throttle is opening all the way Then verify the firing order 1.8.4.3.6.5.7.2 clockwise
  9. Bt Doctur

    MCM260 Problem

    try using the other hole in the shifter cable mount http://www.marine-j.com/pdf/teleflex_sl3.pdf https://www.manualslib.com/manual/2776328/Morse-Sl-3.html
  10. Bt Doctur

    Hydraulic ram stuck on pin

    Why does everyone think a BFH always fixes things
  11. Bt Doctur

    Changing outdrive on my inline 6 165 HP.

    there still available on line for free if you look for them
  12. Bt Doctur

    Reservoir bottle empty - Can they leak from the bottom?

    More likely the housing is cracked where the bolt goes thru
  13. Bt Doctur

    Alpha 1 Gen 2 trim seal replacement

    there is oil in the upstroke and the down stroke.you will lose it all but you should have a means to refill it. cycling it a few times will purge and air
  14. Bt Doctur

    Hydraulic ram stuck on pin

    LOSE the HAMMER Get your self a pitman arm puller and slightly modify the ends to fit behind the cylinder. once removed use a 3/4 inch plumbers wire brush to clean the insides of your clyinger untill the bushings slide right in
  15. Bt Doctur

    Changing outdrive on my inline 6 165 HP.

    thats your shift slide on all drives except Bravo`s
  16. Bt Doctur

    Water pump water port and bolt thread

    use the correct length bolts and you will be just fine
  17. Bt Doctur

    Mercruiser 3.0 TKS - Hard to start when semi-cold

    remove the anti-tamper and open the jet about 2-3 turns
  18. Bt Doctur

    Alpha1 and Alpha1 Gen II U joints

    There are two different U joints for these drives listed. Early for MC1 and Alpha1 and later for Alpha1 and GEN II type, Installed mine last year and missed the size difference in the cups. Never needed to trim up when running so never felt the banging.Heard the noise and pulled the drive and...
  19. Bt Doctur

    Flushing raw water side of 5.7GXi-HF

    I think your over thinking a problem that does not exist
  20. Bt Doctur

    3.7 gets hot while idling

    most likely a clogged/restricted exaust elbow
View older results
Top