Search results

  1. Faztbullet

    '89 Johnson 60HP overheating

    Must not have worked on many Johnrudes Sea.......the seat is rubber an the cup is S/S. Just take a pick and roll the old one out and lube up the new one,pinch into a oval and insert and work back into place. If you remove the whole thing the the cup can be a bear to reinstall as angle and driver...
  2. Faztbullet

    91 mercury 115 flooded then no spark

    Do a DVA test as sometime the ohms test will lie to you...
  3. Faztbullet

    Reliability of 1998 25hp EH

    Find a cycle shop as many use these type cylinder now
  4. Faztbullet

    Need parts

    Same as a Tohatsu............
  5. Faztbullet

    91 mercury 115 flooded then no spark

    The OP motor is NOT a CDM ignition motor it a ADI ignition. This works very similar but trigger is what tells CDM or SCR to discharge capacitor. It dont care how many cylinders as trigger magnet is set length and pass coils the same amount of time regardless of RPM. Also the stator is just a...
  6. Faztbullet

    Advice for outboard setup needed....

    Sorry but disagree as motor runs in water from tunnel.. Have several duck hunters with aluminum tunnels hulls. Here a CS with same design with standard 48HP
  7. Faztbullet

    Advice for outboard setup needed....

    Nothing smaller than a 75Hp...
  8. Faztbullet

    91 mercury 115 flooded then no spark

    Read this several times....UHHHHH???? Stator and trigger DVA voltages has nothing to do with number of cylinders....all RPM related
  9. Faztbullet

    1990 Evinrude 60 Rough Idle and Bogging

    Put NEW OEM kits in carbs...
  10. Faztbullet

    Evinrude tilt and trim.

    Wont matter a single or three cylinder trim wont fit into the old style mid section...77 used the clamp on trim with wing.
  11. Faztbullet

    What shaft size?

    It had a Merc Inline on it originally....most likely a 20"
  12. Faztbullet

    Evinrude tilt and trim.

    Ah No.....
  13. Faztbullet

    '89 Johnson 60HP overheating

    That's a real simply cooling system...if it doesn't overheat at idle as stated and only intermittently at WOT check the seat in head that the T-stat housing which also is the poppet valve, sets in. These do degrade and will swell restricting flow thru head at WOT. Also pull head and check upper...
  14. Faztbullet

    91 mercury 115 flooded then no spark

    Merc did make a 115Hp V-6 but think it was in late 90's early 2000
  15. Faztbullet

    Rebuilding 1985 mercury carburetors

    Trigger or switchbox.....
  16. Faztbullet

    Reliability of 1998 25hp EH

    Look on FB marketplace...there is a 98 25hp Merc electric for $1200 OBO in Hendersonville.
  17. Faztbullet

    91 mercury 115 flooded then no spark

    Flooding will not make spark quit on tester...sound like stator problem.
  18. Faztbullet

    1990 Mercury 25HP Carb questions

    Initial mixture setting is 1-1/2 out from light set then fine tune. Float height is 1"
  19. Faztbullet

    '97 and '02 merc 25s underflywheel differences

    The 97 has a switchbox/coils and the 02 has CDM modules. Yes you could swap it if you have all the 02 ignition system.
  20. Faztbullet

    2001 Yamaha HPDi 150 Twins

    Cause there is more parts taking up room in housing...usually 3-5 oz difference.
Top