Search results

  1. alldodge

    Do new fuel pumps come with a filter pre loaded

    Yes there should be a filter in the new pump, filter kit item 2 https://www.mercruiserparts.com/bam/subassembly/30920/2330/60
  2. alldodge

    Volvo Penta AQ131D getting hot

    Welcome First are you sure it's getting hot, as in has it been checked with a IR temp gun on the thermostat housing? If it is getting hot check the hose connection on the drive that connects to the hose to the raw water pump. Many times they get clogged up
  3. alldodge

    Wiring Diagram 2001 Crownline 266 BR

    Welcome Moving you to Merc section do to fuel pump problem What is the issue?
  4. alldodge

    Water Pump Cycling On/Off Quickly!

    Might need another pressure switch, most should cycle between 20 to 40 psi https://www.xylem.com/siteassets/brand/jabsco/resources/manual/31620-water-pressure-pump.pdf
  5. alldodge

    ECU pinout/wiring diagrams ???

    Do you have a scanner, and was there any codes? Might help to narrow it down Assume they are both mechanical shift and not DTS I'm looking at Merc just to maybe get some clues if they did something different Another thought, wonder if Bob at OBD Diagnostics might help. He does repair and...
  6. alldodge

    I have a 1989 mercruser tops out at 3000 rpm

    False
  7. alldodge

    ECU pinout/wiring diagrams ???

    Was thinking you might know if there were any pin out differences and just mention those. OP would know his serial number but probably not the other harness. Looks like way more complex I guess, each serial number could be different
  8. alldodge

    1996 ski sanger 315hp black scorpoin multi fuel injection.

    Welcome Looks like ya have a motor problem and not a boat problem. We might be able to help if we knew what motor you have.
  9. alldodge

    converting TKS choke to electric choke

    Welcome With fuel in the carb bowl, put throttle handle in "throttle only" and move handle to full WOT and back to idle (keeping handle in throttle only) This should cause the choke to close and accelerator pump should squirt gas down the throat Crank motor, if it doesn't start in a few...
  10. alldodge

    2006 3.0L TKS runs well for a few minutes but then won't restart

    It's an electrical problem and the Bat is showing 90% charge if your meter reads correctly. I would start with cleaning all the Battery cable ends, including the ground cable attached to rear of block. Disconnect the 10 pin engine harness and clean the pins Could be corrosion on any contact...
  11. alldodge

    ECU pinout/wiring diagrams ???

    Hey @muc can you advise?
  12. alldodge

    Anyone please help with my mercruiser 5.7 thunderbolt v igntion engine, hard to start

    Welcome What is the motors serial number?
  13. alldodge

    2007 5.7 Gi-G SX-A trim non-functional - H220

    With relay clicking then they are working, might not be passing current to the motor. This is the wiring from the handle to the relays. Need a voltmeter and follow the voltages Here is a couple pics showing wiring and connections
  14. alldodge

    Maybe my turn for new boat time

    That might be an option, don't know how boat is rigged with the Verado's Still need to get behind the helm to do other things, need to look into it
  15. alldodge

    1996 3.0lx won't start after new fuel pump install

    Making me scratch my head, the LX doesn't use a pump rod so what was the part number of the one you used. https://www.mercruiserparts.com/bam/subassembly/30920/2330/60
  16. alldodge

    Maybe my turn for new boat time

    Hope so, but went from Rinker 232 to Furmula 27PC and never ran into this kind of stuff. It's like someone that never drove a boat before some times
  17. alldodge

    1996 3.0lx won't start after new fuel pump install

    That would increase the idle mix but shouldn't cause that much of an issue. Could be the carb needs rebuilding. Carb was doing ok with lower then normal pressure from the pump. Install new pump and pressure is back up and the float needle seat is not able to keep the increased fuel shut off...
  18. alldodge

    Maybe my turn for new boat time

    I have VV and it doesn't show that. Contacted Merc and asked that question and they said no. I have electric hydraulic steering I could put one of those stick on rudder indicators that is used by inboards, might help
  19. alldodge

    2003 Crownline initial starting problem

    Thanks Gi-B MPI with flat Dizzy cap (crap cap) The distributor caps are called crap caps because they can look brand new and still have problems. Not saying this is your issue but we tell folks with one of those should replace and if it doesn't fix the issue, keep it because it will show it's...
  20. alldodge

    1996 3.0lx won't start after new fuel pump install

    Welcome When you pump the throttle does fuel squirt down the carb?
Top