1994 225 Yamaha SWS- 2 stroke.

[rodbolt]

Re: 1994 225 Yamaha SWS- 2 stroke.

hello wahoo51<br /> sorry if ya think I left ya high and dry. life got in the way of iboats for a bit . what do ya need help with again. refresh me where we are at and what you need. have you gotten the new caps yet ?<br /> anyway post back and ill try to look for it<br /> Good luck and keep posting

 

[Lloydramdeen]

Re: 1994 225 Yamaha SWS- 2 stroke.

rodbolt..<br /><br />I understand that you are busy.<br /><br /> I got the new caps ..the two tops ones are bad.Will put them in on Saturday and use Yamalube. Will this make a difference ?<br /><br />Also the problem of reconnection of the VRO.We could not find where the 4 wired loom from the remote tank was connected. We used a diagnostic light to do the testing of the electrics but got no reading. Presumably as a result of the break in the circuit as a result of the VRO disconnection..we are checking another engine also a diagram in the manual.<br /><br />Any suggestions ?<br /><br />If she runs well after we put on the new caps, perhaps I will hold off on the re-installation of the VRO for a while.<br />thanks

 

[rodbolt]

Re: 1994 225 Yamaha SWS- 2 stroke.

hello<br /> If I can remember today at work I will look at the engine your dealing with. we have a few there. then I can tell ya exactly what to do. did they remove the oil pump and linkage? did the enine oil tank get removed?how much of the system is missing?<br /> good luck and Ill try to check back tonight

 

[Lloydramdeen]

Re: 1994 225 Yamaha SWS- 2 stroke.

we have everything just to connect this loom coming from the remote tank..everything is there.what was done initially was just a blocking off of the oil line.it was cut and a bolt put in it to stop it from leaking.. and the loom wire from the tank was chopped off.

 

[Lloydramdeen]

Re: 1994 225 Yamaha SWS- 2 stroke.

Rodbolt,<br />The whole thing seems stator related , one of the problems you hinted from the beginning. The reading , 32 volts. We found this out after the motor shut down as usual and would not start again although it turned over. The tech had a spare stator and once he made the exchange, it started again on the button. I have to buy one today. Got any idea of how much they cost in your neck of the woods? Just comparing as they could run about $400 USD here.<br />Thanks.

 

[rodbolt]

Re: 1994 225 Yamaha SWS- 2 stroke.

hello<br /> I am at school this week. I cant get to parts smart until next week. I am in a yamaha service school again so I am kinda limited.<br /> any 375 or so is about how it runs here.<br /> I have found they can test good but still fail a voltage out to the CDI. good luck and keep posting.

 

[Lloydramdeen]

Re: 1994 225 Yamaha SWS- 2 stroke.

Rodbolt,<br />Shopped around and the best price so far was on Boat.net. Central Florida. $442.29. so I ordered it . Should be here in 10 days. still has the used of the borrowed one from the tcch which will be removed when the new one gets here.<br />thanks, will let you know the outcome.

 

[rodbolt]

Re: 1994 225 Yamaha SWS- 2 stroke.

hello wahoo51<br /> cool <br />I hope it solves that problem. <br /> let me know. its rare to have electrical problems with yammis but when ya do its expensive. the dissapearing voltage is a tough one to find cause you have to be running when it happens with your test gear attached.<br /> good luck and let us know how it worked out

 

[Lloydramdeen]

Re: 1994 225 Yamaha SWS- 2 stroke.

Rodbolt<br /><br />We have replaced the stator coil and the problem is solved. Lots of difference.<br /> -Rpm is now stable with no spontaneous fluctuation in revs at idling or when running.<br /> - motor restarts quite easily when hot as opposed to how it was before.<br /> - no fouling of plugs, plugs are of a light chocolate color and dry.I have put the reinstallation of the oil injection on hold for the time being, premixing at 50/60 to one on the troll.<br /><br />I am getting a service manual and a voltmeter as I had to assist the tech with trouble shooting.<br /> <br />One other slight problem with" hard gear shifting" at times, which I will raise another heading as I dont want to make a record of my postings.<br /><br />thanks a million.