CHARGING SYSTEM

R

ROTTYRAS

Cadet
Joined
May 11, 2005
Messages
9
MY MOTOR 90HORSE MARINER SERIAL#6572944 LETS SEE STARTS UP AFTER I CHARGE BATTARY THEN AFTER RUNNING 5 MIN IT DIE'S OR IF I PUT A LOAD ON. BATTERY NEEDS CHARGED AGAIN CARBS BEEN CLEAN FRESH FUEL NEW PLUGS COMPRESSION CHECKED OUT ONLY TOP PLUG FIRING IS ONLY ONE CYL RUNNING???CHECKED STATOR IT WAS FINE I HAVE POWER TO EVERY COIL I TIRED TO TEST REGULATOR NOT SUCCESSFULL TACH NOT HOOKED UP CAN SOME ONE HELP COULD IT BE SWITCHBOXES I DONT KNOW I HAVE A MARINER SHOP OUTBOARD MANUAL IT USES RX1000-RX100 SCALE WHAT IS THAT ON MY MULTI TESTER AND IF IT STARTS FINE HOW COULD IT BE RUNING ON ONE CYL ONLY TOP PLUG FIRING ON INLINE SIX DOES THE REST FIRE AFTER THE GHARGE UP OR WHAT I DONT KNOW I HAVE ANY INFO ELSE THAT YOU NEED PLEASE HELP ROTTYRAS@MSN.COM
 
L

Laddies

Banned
Joined
Sep 10, 2004
Messages
12,218
Re: CHARGING SYSTEM

That year mariner does not depend on 12 volts to run the engine, so you must have 2 problems the only part that is common to the two is the stator, you have checked that and say it's OK, so maybe the rectifier is back feed it causing it to build heat and break down after a few minites of running, nexxttime you try to run it disconnect the 2 yellow wire from the rectifier, tape thme off and see if it runs, it wont charge the battery but if the battery is any good it should run a couple of days anyway there are many starts in a good battery--Bob
 
R

ROTTYRAS

Cadet
Joined
May 11, 2005
Messages
9
Re: CHARGING SYSTEM

THANK YOU FOR SOME KIND OF HELP AND I AGREE I CHECK THE REC AND IT SAID TOUCH THESE 2 AND IT WAS GOOD THEN SAID TOUCH THESE 2 AND IT WAS BAD IT SAID TO REPLACE AND THATS IF I WAS DOING IT RIGHT IM GOING TO DO YOUR TEST SOON AS I GET A CHANCE ITS BEEN RAINING ALSO COULD THAT REC MAKE ONLY TOP PLUG FIRE OR THAT HOW IF FIRES OR WHAT????????????
 
You must log in or register to reply here.
Top