Do not run over 3500 rpm

[delgao]

I do have a monterey with 2 mercruiser 5.0 (2000) and one engine runs perfect but the other do not run over 3500 rpm with the trotle widh open (2barrel carb.) Even if it is running perfect.Can somebody help me with any idea?

 

[Don S]

Re: Do not run over 3500 rpm

List of possible causes of low WOT (Wide Open Throttle) rpm.

In no particular order

Engine Won't Reach Operating RPM. Check

1. Fuel condition. Type and Octane possibly old fuel
2. Propeller pitch or diameter, damaged blades
3. Restricted fuel pickup tube or anti siphon valve Fuel System Test
4. Crankcase oil volume, high oil level can cause aerated oil and lifter collapse
5. Marine growth on hull and outdrive
6. Wrong gear ratio in outdrive
7. Restricted carburetor air intake (clogged flame arrestor)
8. Restricted exhaust system (broken exhaust shutters/flappers) in engine transom shield or drive
9. Poor cylinder compression Compression Test
10. Carburetor defective, or wrong type.
11. Fuel pump pressure and vacuum
12. Boat overloaded, improperly loaded, or improperly trimmed.
13. Engine Overheating
14. Engine timing and ignition system operation
15. Remote control cables and linkage for proper travel to open throttle plates fully.