Search results

  1. Bt Doctur

    manual for water dist housing motor

    Can somebody tell me the manual for the motor with a water dist housing that does not have the stem to open the valve.
  2. Bt Doctur

    MST Guardian BT-2000 Failure

    Might want to remove for maintance. This system hooks to the block drains and the manifold hoses.I guess its supposed to flush the motor and manifolds . EXCEPT it dosent work that way once the block drains get plugged with scale and the outlets get plugged up also. Nothing drains and nothing...
  3. Bt Doctur

    Trim.tilt link

    Found this surfing the net, pretty informative http://cemrweb.cemr.wvu.edu/~mathews/boat/pdf/manual/Chapter%20Eighteen.PDF
  4. Bt Doctur

    A Darwin Award Winner, Trenton,NJ

    In the news, 2 Darwin Candidates on a jet ski ran aground in the Delaware River and were ejected. 1 saved by passing vessel, the other is a candidate for the Darwin Award when they find his body. Did these people ever hear that nobody ever drowned wearing a life preserver...
  5. Bt Doctur

    Need a second opinion

    This boat has under 15 hours on the clock and was stored for 10 years. Upon retreival from storage this was found
  6. Bt Doctur

    somebody asked about stainless steel props

    somebody asked about stainless steel props and the damage they cause. this was a Black Max outboard at full throttle meeting a boulder The other photo`s are too painfull to post
  7. Bt Doctur

    Volvo Penta raw water pump bearing replacement.

    For info pm me
  8. Bt Doctur

    And you thought flying was easy too? CJ 525 water landing

    Narrative: The CitationJet departed Burlington (BTV) around 14:45 on a routine flight to Atlantic City (AIY). The pilot first made a low pass down runway 29 and then return to land on runway 11. After touchdown the airplane failed to stop and overran the runway and into the Intercoastal...
  9. Bt Doctur

    post reponses not updating

    The replies to the posts are not updating . can be 5 replies but original posting always shows 0
  10. Bt Doctur

    A Bad vibration, whats wrong

  11. Bt Doctur

    Bravo 1 CR shift question

    Almost positive I know the answer but would like confirmation. A CR unit is CR because of the way it shifts. Meaning a STD or CR is determined by how the control cables are installed. The upper gear set dosent know the difference because of the cone clutch.?
  12. Bt Doctur

    possable replacement for the shift interupter switch??????????????

    product detail - quickview close X V7-1A27D8-207 HONEYWELL Switch Snap Action N.O. SPST Roller Lever Quick Connect 5A 277VAC 0.84N Screw Mount View Data Sheet Authorized Distributor [/TD]...
  13. Bt Doctur

    how to install the miissing grease fitting Bravo, Alpha

    locate the center of the pin ,can be done visually Drill in 3/8 ths of an inch with a #3 drill bit for 1/4 x 28 thread and tap . using a 3/64 drill bit CAREFULLY drill approx. 3/4 to 1 inch into the housing until the magnet picks up steel shavings.STOP DRILLING. Install grease fitting.inject...
  14. Bt Doctur

    idler pulley replacement

    Same exact part, same numbers , available from your local auto store for about the same price. this part number is for the smooth pulley
  15. Bt Doctur

    Winterizing tip to prevent cracked blocks

    This only applies to those equipped with single point drain systems. This is the 3rd boat that I have found the block drains "blocked" with scale. You MUST remove the quick connect hose and probe the engine block drain holes . Failure to do this critical stem will most likely result in a cracked...
  16. Bt Doctur

    contaminated fuel

    working on a 6.2 that would not get out of its own way, would only turn 3100 rpm. Cool fuel unit was replaced under warranty but fuel press was pulsating 42-46 psi . Suspecting bad injectors, they were remove and sent out for cleaning. 7 were in poor condition for fuel flow and balance. cleaned...
  17. Bt Doctur

    Tech Tip with the single point drain system

    Tech Tip with the single point drain system, be sure to remove the quick connect fittings on both sides of the block. They do close with scale and corrosion . The same thing happens with the so-called flushing system. The block connection become closed from corrosion and will not allow it to...
  18. Bt Doctur

    Winterizing a fuel injected/ throttle body motor

    Getting close to the close of another season so do it right or pay the price. You CANNOT spray fogging compound into a fuel injected motor`s intake. you will ruin the sensors. You need to make up a small gas can with the winterizing cocktail and hook it to the fuel inlet. Gas, Stabilizer...
  19. Bt Doctur

    REPLACED BY 32-861213 hot pipe from exaust manifold to intake manifold NLA

    For those that have this pipe going from the exaust manifold to the intake manifold a very short natural gas whip dies the trick and comes with the correct threaded fittings too. and is stainless steel
  20. Bt Doctur

    The " It suddenly stopped running" story again

    Got to hand it to the engineers on this one. 3 year old boat with the new emission package, cats, etc. operated very well the day before, the next day it was a no start. no fuel delivery, no fuel pump pre-prime sound. Everything else worked. All engine breakers checked, all ENGINE fuses checked...
Top