Search results

  1. Fun Times

    Outdrive identification. VP

    If only the block was replaced and not the engine accessory components then the ID numbers should still apply to get the correct blot on component accessories at the very least. 3868718 is the product number which helps shows the drive to be a SX-C2 as suggested...
  2. Fun Times

    Need this part #

    What liter size is the engine? Serial number handy? It probably be, 10 27-8637251 https://www.mercruiserparts.com/bam/subassembly/31835/1014/190 GASKET 41811 SS/ACT $15.90 $15.51 2 But without more info, it's a guess. ;)
  3. Fun Times

    Merc 5.0 TKS Heat Issue

    To start off with, it sounds like you may want to consider buying yourself an infrared thermometer gun and check the temp yourself compared to what the temp gauge and dealer is suggesting so you'd know more where to start. You should have a 160 degree thermostat so in some cases it wouldn't be...
  4. Fun Times

    Signature 31 Throttle Cable Length?

    https://www.ebay.com/p/1727670303 That would be correct with the last numbers being the foot length of the cables as shown in the 1 link above using just 1 of your part numbers ending in 26.., Those are like the good cables I was starting to reference from Volvo. Now that you have the part...
  5. Fun Times

    Where does this little hose go from the thermostat housing?

    Yes it'd run to the VST system...Item number 29, Volvo Penta Exploded view / schematic Vapor Separator Tank 5.0GiPBYCCE, 5.7GSIPBYCCE - MarinePartsEurope.com
  6. Fun Times

    Signature 31 Throttle Cable Length?

    There should be some numbers on them usually found sort of near the ends of the cables.... If you can find them numbers you can usually find a size conversion chart online at marine retail type stores that should be able to help match what you have now should the cable not tell you the exact...
  7. Fun Times

    Where does this little hose go from the thermostat housing?

    That hose goes to the fuel pump assembly to help keep it cooler....Item # 10,
  8. Fun Times

    98 4.3 GL Fuel Pump Connector

    Some places online offer the wire harness pigtails you could solder in place such as these, https://www.ebay.com/sch/i.html?_from=R40&_trksid=p2047675.m570.l1313&_nkw=VOLVO+PENTA+OMC+MERCURY+FUEL+PUMP+WIRE+HARNESS+PIGTAIL+PLUG+CLIP+3858261+3857650&_sacat=0 You can sometimes even find these wire...
  9. Fun Times

    Broke off Starter bolt in the block

    I've been lucky like this with the starter bolt a few times as well. Are you able to get the starter removed since the 1 bolt head is missing? Also check the starter screw hole areas on the engine block for cracks using a mirror.
  10. Fun Times

    2000 Volvo Penta 5.7 Gsi PEFS Fuel line fitings

    Yes you can use AN type fittings for the fuel system and here are a few examples to show confidence it's been done in the marine world, https://www.summitracing.com/search?SortBy=BestKeywordMatch&SortOrder=Ascending&keyword=AN%20fuel%20fittings%20marine%20use...
  11. Fun Times

    1983 Mercruiser Sterndrive - R

    Think you'd have to pay for this one to fully work Mercruiser Service Manual 6 Outdrives R/MR/Alpha One/Alpha SS | Paint | Nut (Hardware) (scribd.com) Possibly look a private message from @Bt Doctur as he may have one on file should this one not work for you, Boatinfo - Mercruiser Service...
  12. Fun Times

    Windshield interchangeability 2005 H190

    If the Four Winns® Boat Owner Resources, Accessories & Manuals &" Parts Catalog " website section comes back online soon, try inputting your F_W hull ID number and see if you can locate the windshield part number and call a dealer and see what they might be able to do.... Maybe check with Search...
  13. Fun Times

    2008 four winns H220

    Search online "four winns snap in replacement carpet" as you may find more info but here's a few places to start with that may help, Four Winns Kits (snapincarpet.com) Search results for: 'Four Winns' (greatlakesskipper.com) Four Winns Cockpit Carpet Sets - Matworks Ltd Premium Custom...
  14. Fun Times

    MerCarb adjusting after rebuild and question about base gasket

    That should work okay.
  15. Fun Times

    Prayers needed please ...

    🙏For you and yours Sam.🙏
  16. Fun Times

    MerCarb adjusting after rebuild and question about base gasket

    Running your 807764 number shows it ought to come with the 2 hole gasket, https://www.mercruiserparts.com/864941a01-carburetor Looks like the main difference between the 2 are thickness. Gasket thickness: .060" is for the 1 hole and the 2 hole Gasket thickness is .030''...
  17. Fun Times

    Indmar Raptor Crank Sensor & Cam Sensor Faults

    Don't have a service manual to confirm but generally I believe those 2 sensor circuits share the same grounding wire circuits. Make sure the small grounding for the ECM usually at the rear of the engine are really good, clean tight, not damaged, etc.... Plus check the wires at each sensor (find...
  18. Fun Times

    MerCarb adjusting after rebuild and question about base gasket

    It's been a awhile now but I believe it was because on some setups there was a engine running issue that arose as one of the fuel flow circuits became obstructed with the 2 hole cut out at the top so they opened the gasket up starting at the next set of serial numbers above the you...
  19. Fun Times

    MerCarb adjusting after rebuild and question about base gasket

    Carburetor Kit for (TKS) looks like this... While Carburetor for (Mercarb) = this set up, Carburetor and Throttle Linkage https://www.mercruiserparts.com/4-3l-carb-alpha-bravo-0m615000-thru-0w
  20. Fun Times

    Mercruiser ECM Failed?

    Please keep this topic updated as you go and good luck to you.
Top