Search results

  1. W

    2006 Volvo 5.7 osi-d crank no start

    In neutral the drive wouldn’t create friction would it ? Impossible to turn by hand with plugs out and in neutral
  2. W

    2006 Volvo 5.7 osi-d crank no start

    It’s says starter relay on the fuse box, about 5 pins from memory. Just wondered if it may be that …. Trying anything at the moment, such beautiful weather it’s doing my head in seeing all the boats out 🙄
  3. W

    2006 Volvo 5.7 osi-d crank no start

    Should I have any ohm reading on my starter relay ? I can’t seem to get a replacement here. When I take starter relay out of my chev Ls1 engine at home I have similar crank no start symptoms…. Just a thought
  4. W

    2006 Volvo 5.7 osi-d crank no start

    No engine/ignition lights anywhere on dash Getting two beeps with key on 10 point plug for diagnostic connector and yes, sits by SB riser Thanks for email too
  5. W

    2006 Volvo 5.7 osi-d crank no start

    Problem is in NZ it takes a month to get here. I’m thinking timing maybe but I can’t get the motor to stop at TDC. Took plugs out but can’t turn motor…. Maybe I need to take water pump off the crankshaft first ?
  6. W

    2006 Volvo 5.7 osi-d crank no start

    Ok, I think I may have to concede defeat. Have checked firing order, plugs, run new fuel after purging old. I can’t get it scanned for a few weeks as Volvo here are very busy. Pulled IAC valve just now, seems to extend when I put throttle to full but doesn’t retrAct, maybe that occurs when it...
  7. W

    2006 Volvo 5.7 osi-d crank no start

    I’m sorry AD I don’t understand what you’re saying there … not the best with electronics
  8. W

    2006 Volvo 5.7 osi-d crank no start

    It’s around 10.6 at CPS, is the lack of any voltage at MAP connection an issue ?
  9. W

    2006 Volvo 5.7 osi-d crank no start

    Ok …. 5 v at temp sensor connection, 10 at CPS and I cannot get any reading off the 4 pOINTS of MAP connection
  10. W

    2006 Volvo 5.7 osi-d crank no start

    Will check
  11. W

    2006 Volvo 5.7 osi-d crank no start

    Just tried spark tester, getting a 1 inch spark from coil lead and about 1cm from plugs. Going to try to get some fresh fuel through it and also check dizzy position at tdc …. I presume I have to take all plugs out to be able to turn the motor to find tdc ?
  12. W

    2006 Volvo 5.7 osi-d crank no start

    I have wondered about gas…. Heading down soon so will try a few things you both mention and report back, thanks again for your help… beautiful weather here and I’m stuck on shore 🙄
  13. W

    2006 Volvo 5.7 osi-d crank no start

    Ok thanks, with spark at plugs does that not eliminate bad dizzy cap ? Just that they take like 3 - 4 weeks to get here in nz and about $400
  14. W

    2006 Volvo 5.7 osi-d crank no start

    I’m getting the odd “pop” when cranking it over
  15. W

    2006 Volvo 5.7 osi-d crank no start

    Will put original dizzy cap on. Timing/alignment shouldn’t have changed should it by changing cap
  16. W

    2006 Volvo 5.7 osi-d crank no start

    If tach is showing 300 ish rpm does that confirm cps wiring is ok ? Tach used to swing wildly occasionally when running at say cruise speed, 22 kts, would go to zero, up to 3-4000rpm and flick all over the show. It’s been hard to start when hot, requiring full throttle, for some time.
  17. W

    2006 Volvo 5.7 osi-d crank no start

    Thanks again, yep, getting about 300 rpm on tach at crank. Tried cleaning ALL connections with an electrical cleaning spray recently. Could it be the cps wire grounding ? Does spark need to be any strength or just spark, some say must be blue. Wouldn’t be engine grounding or something ?
  18. W

    2006 Volvo 5.7 osi-d crank no start

    thanks for your reply, I have tried that, forgot to mention in original post. Troy at man cave mechanic helped me with the potential fuel cell issues. There was no fuel coming from there on cranking, of course I don’t know when running as I can’t get it running.
  19. W

    2006 Volvo 5.7 osi-d crank no start

    Think it’s 4012166934
  20. W

    2006 Volvo 5.7 osi-d crank no start

    Can you read the attached alldodge ?
Top