Search results

  1. alldodge

    Another Plumbing Question

    Not here, City water and Pex from meter to house My house has copper from meter in to house and all copper pipes. Have regular metal electric water heater with diaelectric unions on in and out and very little corrosion but there is a trace after 4 years so far.
  2. alldodge

    Another Plumbing Question

    Good thought, have looked quite a bit on the electrical side. Main panel is done correctly from what I've seen, disconnect is good House built in 2007 and all water lines are Pex except where lines come out of the wall. Being there is no ground except from power feed, it sure looks to be from...
  3. alldodge

    Replacement ignition coil

    Take with grain of salt, but new 9.9 appears to use same coil but has different connectors 803559A02 It is $112 https://www.mercruiserparts.com/803559a02-ignition-coil
  4. alldodge

    Electronic issue, no power pole, gps or radio power

    Check fuses and Battery switch. My guess is there is a bad connection. Might remove and clean up all the cable ends You should not use BOTH unless you need it to start the motor. Leave it on Start Bat (probably 1) and use the Bat charger to charge Bat 2 when you get back home. If your motor...
  5. alldodge

    Another Plumbing Question

    Don't know but the tank is about 2 years old, and it is a bladder tank so no metal in it. I changed it out to all brass so I'll keep a watch on it
  6. alldodge

    Mercruiser 4.3 Temp Alarm Question

    The Tan/Blue is on the Temp switch that is on one side of the thermostat housing. The Temp gauges sender is on the other side of the housing.
  7. alldodge

    Alpha One Gen II shift shaft seals

    Good point the B3 has oil on one side and water on the other.
  8. alldodge

    Mercruiser 4.3 Temp Alarm Question

    Yes TKS No mention of the motor stumbling when alarm is heard so it should not have anything to do with TBV module (knock, over speed, over Temp) Think this is either the lube bottle float sticking or a chafe on the Tan/Blue wire. The TKS takes the over Temp switch and sends it through the TBV
  9. alldodge

    Alpha One Gen II shift shaft seals

    I agree with your assumption, the lip should be toward the water so it will have a better chance of sealing Similar issue with seals and the B3 prop shaft. Early (manual 11) has 2 seals and states to place seals in facing each other. First (inner) lip faces out and Second (outer) faces in...
  10. alldodge

    Mercruiser 4.3 Temp Alarm Question

    Pull one of the leads off the lube bottle and see if it does it again. If it does reconnect bottle Have IR Temp gun and when it beeps measure thermostat housing. If its good, disconnect Temp sensor (the one with 2 wires) BTW does motor have a TKS carb?
  11. alldodge

    Gimbal Bearing Cheap

    You can't pull and not damage the bearing because the puller applies all forces to the inner race. The installer applies forces to outer race It's not going to just go out. Just use it
  12. alldodge

    Gimbal Bearing Cheap

    Hope your right. The grease will squeeze out around the outside of the bearing if the hole is not aligned
  13. alldodge

    Gimbal Bearing Cheap

    RPS is a Korean company The USA hasn't made much in the way of bearings for many years. Temkin, SKF and others while they still make bearings not many are done here I look at it this way, that bearing once the drive is off takes maybe 30 minutes to remove and replace with proper tools. Easy...
  14. alldodge

    Gimbal Bearing Cheap

    I'm just going by the pic and part number listed, it shows the hole same as the ones I have
  15. alldodge

    Gimbal Bearing Cheap

    Can you clarify a bit more? Merc went from greasable to sealed type a few years ago and this type is getting hard to find. I have 2 of them and when i sold my 95 Rinker it had the original bearing in it If you don't have a grease fitting on your transom assembly then you should have installed...
  16. alldodge

    Gimbal Bearing Cheap

    Found this looking up prices and folks may want to get a spare at this price $27 and free ship Greasable type https://www.amazon.com/GIMBAL-BEARING-MERCRUISER-VOLVO-PENTA/dp/B018WLJAQ8
  17. alldodge

    Engine lift point - Lifting Eye question

    Yes, that will work I like using two 1 inch wide lifting straps. Place the straps length wise under the exhaust manifolds and they come together above the intake
  18. alldodge

    Volvo Penta sea water pump

    Search "Johnson F5B-9 pump" it will show show up
  19. alldodge

    Volvo Penta 5.7 no spark

    The worst thing IMO about VP is finding a dealer, next thing is finding one that is good enough to fix the issue. This is the reason I don't buy VP, Yam, Suz, nothing but Merc I'm in KY and the nearest VP Dealer is in Virginia. Take that and folks that sell Boats with VP drives and motors are...
  20. alldodge

    Can I switch out Mercury 9.9 kill switch?

    I was thinking right but typing wrong. You need a NO switch and it will make a connection (close contact) when pressed which grounds the magneto
Top