Search results

  1. R

    2002 johnson 115 2 stroke starts then dies, heavy smoke.

    The red lever should be in line with the valve body to run.----When you turn that lever it opens the valve and sprays fuel into the engine.----So have the red lever inline with valve body.----Push key in and hold it in while cranking the motor for cold start.----You should find an owners...
  2. R

    Gas tank pressure fueling up!! 🤬

    I would say the vent screen or hose is plugged.
  3. R

    OMC sterndrive not moving in gear.

    You turn one ( input ) shaft a full 10 turns.-----And you count how many turns the output shaft turns.----Simple enough in my opinion !!
  4. R

    No spark on my 1984 115 horsepower TOP

    see post#4
  5. R

    No spark on my 1984 115 horsepower TOP

    Key needs to be pushed in while cranking it over.----Battery should be load tested even if new.----Starter motor should be taken apart and inspected / ohm checked.-----Motor needs a new impeller before launching the boat !
  6. R

    1984 Evinrude 235 cylinder head cover torque

    There are oil recirculation hoses.-----And there are wee hoses from the electric primer valve..------Electric primer VALVE is used for cold starting.-----Key is to be pushed in while cranking it over for near instant starting.
  7. R

    2005 115 Johnson PLSOR dies at idle

    There may be a leak in your tank.----Simply test run with another tank.----Borrow one if you have to.----There is nothing scary about carburetors.----And this issue might be as simple as turning idle mixture screws a wee bit.-----Wonderful time to learn or pay $120/ hr at the shop.
  8. R

    1984 Evinrude 235 cylinder head cover torque

    I have 2 ( 1982 ) of these motors on my boat.----If compression was 75 PSI on them they would come apart in a heart beat !!!-----Install a new impeller before launching the boat.
  9. R

    First start of oil injected 2 stroke after sitting for 4 years

    Too much oil will do no damage to the motor.-----Owners of oil injected motors need to test / keep an eye on the injection system.
  10. R

    1984 Evinrude 235 cylinder head cover torque

    The 1/4-20NC bolts are 60 to 80 inch lbs.----inch-lbs
  11. R

    under powered mercury 125 / 2 stroke

    What boat ??
  12. R

    2002 johnson 115 2 stroke starts then dies, heavy smoke.

    Is it stored with fuel in the carburetors?----Lever on the electric primer in the correct position?-----Pushing the key in while cranking for cold starting ?-----Your location ?
  13. R

    under powered mercury 125 / 2 stroke

    Check spark.----Check flywheel key.
  14. R

    OMC sterndrive not moving in gear.

    The 400 uses gears similar to the 4 cylinder 115 HP outboards.-----The 800 uses bigger gears / housing similar to V-6 outboards.------Check gear ratio of upper gear box.
  15. R

    97 Johnson 50hp 3cyl - idle problem

    Has the motor been stored with fuel in carburetors in the off season ?------Fuel pumps are driven by crankcase PRESSURE on these motors.-----Need to look at adjusting low speed mixture.----Bumping up the idle speed with stop screw.-----
  16. R

    under powered mercury 125 / 2 stroke

    Post compression test results.
  17. R

    2000 225 HO BOGGING OUT

    Need a model # first.
  18. R

    Hi All! I have 68 Evinrude 55hp 66872 R

    Use the manual choke and see if it fires up that way,
  19. R

    20 seconds to start peeing on muffs

    Put a new impeller in one of those 4 cylinder motors last week----Took 7 seconds for tell tale to work like a small / young race horse.
  20. R

    70hp Johnson 2-Stroke 3 Cylinder

    There is only one fuse.------What is your motor doing / not doing ?
Top