Search results

  1. Bondo

    starts then dies

    Ayuh,..... Welcome Aboard,.... The oil pressure switch is on the portside of the block, down low, on the V-motors,..... The fuel filters contents should be examined in a clear bowl to look for anything but clean fresh gasoline,...... 'n of course, screw on a new filter,.... ;)
  2. Bondo

    Outdrive issue

    Ayuh,..... Welcome Aboard,........ Have ya removed the lower shift cable from the shift plate, where it meets the forward cable,..?? If you manually push/ pull the lower shift cable end,..?? What happens,..?? You can do as AD said to manually shift the drive into Forward gear,... The...
  3. Bondo

    1993 omc cobra doesn't want to crank

    Ayuh,..... That smoke is tellin' you that, that terminal connection is corroded,.... Corrosion equals resistance, equals heat,..... I suggest ya clean to shiny metal clean, both ends of both battery cables,....
  4. Bondo

    1989 mercruiser 5.7 ignition

    Ayuh,..... Welcome Aboard,..... That's certainly odd, as the neutral safety switch is in the starter crankin' circuit, 'n has nothin' to do with the ignition circuit,.....
  5. Bondo

    1983 Chris Craft with original Mercruiser 5.7

    Ayuh,..... What voltages are you seein',..?? Where are you checkin' voltages,..?? Are the battery terminals good, clean, 'n tight, both ends of both cables,..??
  6. Bondo

    Head gasket? Cracked head?

    Ayuh,..... The 2 most important are the 2 block drains, one each side, down just above the oil pan, 'bout mid-way,.... There's a winterization thread in Don's Adults Only Section, found at the top of the I/O forums, or in my signature,...... ;)
  7. Bondo

    Engine Bogs Down Under Load

    Ayuh,..... Read the spark plug's color, 'n see if it needs rebuildin' /cleanin' again,..... If it picked up some crud, 'n is goin' lean, you can smoke yer motor in minutes tryin' to really Run it,....
  8. Bondo

    87’ invader mercruiser help me ! 👸

    Ayuh,...... Welcome Aboard,....... That's a 470, I-4, the gear ratio will be just fine,.... You will need a Y-pipe, 'n related exhaust parts,.... You'll probably have to widen the doghouse, 'n you'll need to build motor mounts to hold the V-motor,..... There'll also be some plumbin'...
  9. Bondo

    Engine Bogs Down Under Load

    Ayuh,.... Welcome Aboard,...... What carb,..?? Efi,..?? Mpi,..??
  10. Bondo

    Cranks, No Start

    Ayuh,..... Welcome Aboard,...... You had the distributor way outa time,..... Now, with the hold down bolt barely snug,.... Turn the distributor body to get the timing closer, so it'll start, then set the timin' proper,....
  11. Bondo

    Merc 5.7 High Temps on Intake Manifold

    Ayuh,..... Welcome Aboard,..... Perfectly normal,...... Yer vintage motor has an exhaust cross-over cast into the manifold, under the carb,....
  12. Bondo

    Slow to plane, great top speed?

    Ayuh,.... Welcome Aboard,..... A 21" prop will probably give ya better results,.....
  13. Bondo

    Mercruiser knocks but only after 3,000 RPMs under load

    Ayuh,.... The balance shaft is only in the mid-late model 4.3l motors,.... Detonation sounds likely,...... Dump the fuel filter's contents into a clear jar, 'n check for anything but clean fresh gasoline,.....
  14. Bondo

    Help figuring out how to fix my issue I’m having with my boat.

    Ayuh,..... Welcome Aboard,..... There should be a big silver washer on top of the shift spool in the lower unit,..... That washer pushes the shift foot, up into the shift shoe,.....
  15. Bondo

    350 Mag MPI chugging at higher rpms

    Ayuh,...... Welcome Aboard,...... Dump the fuel filter's contents into a clear jar, 'n check for anything but clean fresh gasoline,......
  16. Bondo

    1991 4.3 Volvo Penta DP-C tilt will not raise outdrive

    Ayuh,..... Welcome Aboard,........ Does the pump run, but not lift the drive, or are you gettin' no response when pushin' the button,..?? If no response, check, 'n clean the wirin' connections at the pump, 'n battery,....
  17. Bondo

    Cracked block - now looking to replace motor

    As I just said,..... No, ya need one,.... the bolt pattern changed in '96,.... The Quadra jet carb can be used though,....
  18. Bondo

    No water out transom or exhaust

    Nope,..... It goes to the in-comin' water port on the T-stat housin', where it's available to both the circulatin' waterpump, 'n the exhaust manifolds,...... A 5 year old impeller is junk,......
  19. Bondo

    Cracked block - now looking to replace motor

    Ayuh,..... 'bout 20 bucks will buy a package of brand new brass core plugs,.... No swappin', they usually get bent up takin' 'em out anyways,.... The truck motor will work just fine for yer conversion, If yer willin' to do a few updates, 'n you'll have a better motor for yer efforts...
  20. Bondo

    Mercruiser 4.3L Just clicks once when trying to start! Help!!

    Ayuh,.... Starters don't like to go swimmin', 'n fail shortly after they do,..... For the replacement, go with a permanent magnet starter,.... 1/2 the weight, 'n twice the power,....
Top