Search results

  1. alldodge

    2002 Volvo penta Gxi 5.0 beeping issue

    The ECM checks to see if the knock sensor is work when the motor is first throttled up after restart. The ECM advances spark to far for milliseconds to see if it can detect a knock. If it does, timing goes back to normal and all good. If it cannot make it knock, then it sets code 44 meaning...
  2. alldodge

    2002 Volvo penta Gxi 5.0 beeping issue

    The AHA moment Would you happen to be running gas with a octane rating higher the 87 maybe?
  3. alldodge

    '09 5.0 TKS (Carb) not running

    It should, the carb is full of fuel and should run for several minutes just idling If it doesn't then there is a short somewhere. Will need a voltmeter to see 12V with key ON (motor not running) on purple wire. Should be on one side of the oil switch and + side of coil. If less then 12V not...
  4. alldodge

    '09 5.0 TKS (Carb) not running

    Once it's running, will it continue to run without the jumper?
  5. alldodge

    2005 Crownline Fuel System Charge/Prime on key turn

    Isn't that the way it goes o_O Thanks for the update and hope it stays that way
  6. alldodge

    '09 5.0 TKS (Carb) not running

    Starter or pump is drawing to much current or pur/yel is shorting out Disconnect pur/yel from starter then jumper oil switch to get it to run. It should run without the jumper once started but find out if still gets hot
  7. alldodge

    '09 5.0 TKS (Carb) not running

    Probably no 12V power going to the motor. By jumping the fuel pump directly it would back feed the the motor. Being a carb once the fuel bowl is filled the motor would keep running until the fuel ran out. When you disconnect power from the pump it dies right away because it also removed power...
  8. alldodge

    Bravo drive is hard to shift into reverse?

    While getting a new upper will fix the issue, some mechanics say to replace because they are not skilled enough or don't want to spend the time. Replacing the gear, upper shift shaft and clutch should fix the drive. Note: some shops use lube other then Merc lube because its cheaper. If they...
  9. alldodge

    Mercruiser 3.0 TKI engine crank half time - never starts

    That's a messy wiring diagram. The ACR is not connected directly to the Bats, but shows it does connect to each and thru switch. The ACR should be direct connect without switches. The trim should be connected to the start Bat With the house Bat not being charged thru the ACR while motor is...
  10. alldodge

    Need Help on 5.8fsi Couple of Issues

    While it hasn't been verified I would believe its electrical. Fuel pressure should have been maintained by hot wiring. As to what's causing it to stop, nothing is giving a clue. Don't know enough about the system and don't have a manual. Just found the manual in DonS post at 4shared, I'm...
  11. alldodge

    7.4mpi just started running rough and with gas coming out exhaust

    yep it was right there The issue of black plugs on one side and white on the other is just weird, unless someone has moved the injector connectors so this would happen. If that's the case, then I would expect this is a ECM issue or a bad connection
  12. alldodge

    Starting issue

    Haven't found a way to lube cables, but most time its the shifter. They can be taken apart and greased
  13. alldodge

    7.4mpi just started running rough and with gas coming out exhaust

    Don't think its either Check fuel pressure. The mefi 1 and 2 has very little smarts. It can show if there is a code, but usually does not provide enough info to designate what the actual problem is Of fuel pressure is high. This can indicate that maybe some if injectors are leaking. Testing...
  14. alldodge

    1998 vip valiant

    Very doubtful you can find good used parts and new are not available. Those items are normally made by by using old parts and making new. Then re-upholster them
  15. alldodge

    Starting issue

    One thing I left out is the neutral safety switch in the throttle handle. Turn key to start and hold, then move the throttle back and forth slightly to see if it engages
  16. alldodge

    Seized engine

    Don't know which drive but Alpha or Bravo needs to sealant
  17. alldodge

    Making sure I purchased the correct coil for a 1996 5.7L

    Items 2, 5 and 6 https://www.mercruiserparts.com/bam/subassembly/31770/1939/50
  18. alldodge

    Mercruiser 7.4 Dipstick Tube Broke, Can't Remove Oil Pan

    Looking a bit longer, I can see the tube has been bent over to the other side. The windage tray is also being bent. The tube bent over against the tray is what's keeping it from coming out. I would try to drill it out If that fails post something in the wanted section of Offshore only...
  19. alldodge

    Mercruiser 7.4 Dipstick Tube Broke, Can't Remove Oil Pan

    Suggest a sawzall and long blade Maybe a drill bit
  20. alldodge

    Mercruiser issues with alarm and guardian mode

    Crate motor complete with exhaust or just motor? If full with exhaust then disregard
Top